Study of partial discharge characteristics in HFO-1234ze(E)/N<sub>2</sub> mixtures

Zongkai JIA (贾宗凯); Qingguo CHEN (陈庆国); Lin LIN (林林); Xinyu WANG (王新宇)

doi:10.1088/2058-6272/ab9f14

Plasma Science and Technology > 2020 > 22(11): 115403. > DOI: 10.1088/2058-6272/ab9f14

Zongkai JIA (贾宗凯), Qingguo CHEN (陈庆国), Lin LIN (林林), Xinyu WANG (王新宇). Study of partial discharge characteristics in HFO-1234ze(E)/N₂ mixtures[J]. Plasma Science and Technology, 2020, 22(11): 115403. DOI: 10.1088/2058-6272/ab9f14

Citation:

PDF (2067 KB)

Study of partial discharge characteristics in HFO-1234ze(E)/N₂ mixtures

Key Laboratory of Engineering Dielectrics and its Application of Ministry of Education, Harbin University of Science and Technology, Harbin 150080, People's Republic of China

More Information

Received Date: April 15, 2020
Revised Date: June 19, 2020
Accepted Date: June 21, 2020

Graphical Abstract

Abstract

Abstract

HFO-1234ze(E)(trans-1,3,3,3-tetrafluoropropene, chemical formula: C₃H₂F₄) is an extremely environmentally friendly SF₆ alternative gas with high electrical strength. In this paper, the partial discharge (PD) characteristics of HFO-1234ze(E)/N₂ mixtures were studied using the gas insulation test platform. The PD inception voltage of insulating gas under positive and negative half cycles of power frequency was tested. Using SF₆/N₂ mixtures as a control group, the effects of electrode spacing, mixing ratio and pressure on the insulation performance of HFO-1234ze(E)/N₂ mixtures were explored. The test results show that the PD inception voltage of the negative half-cycle of pure HFO-1234ze(E) under short electrode spacing can reach 0.96–1.04 times of pure SF₆ under different pressures; the PD inception voltage of 40%HFO-1234ze(E)/60%N₂ mixtures at 0.3 MPa is 0.67–0.89 times that of SF₆/N₂ mixtures under the same conditions, which has great application prospect.
- SF₆ alternative gas,
- greenhouse effect,
- partial discharge inception voltage,
- unevenelectric field,
- relative insulation performance

FullText(HTML)

References (24)

References

[1]	Christophorou L G, Olthoff J K and Van Brunt R J 1997 IEEE Electr. Insul. Mag. 13 20
[2]	Rabie M and Franck C M 2018 Environ. Sci. Technol. 52 369
[3]	Cook E 1955 Lifetime Commitments: Why Climate PolicyMakers Can’t Afford to Overlook Fully Fluorinated Compounds (Washington, DC: World Resources Institute)
[4]	Maiss M and Brenninkmeijer C A 1998 Environ. Sci. Technol.32 3077
[5]	Xiang Z 2010 Chin. J. Environ. Manage. 2 23 (in Chinese)
[6]	Watson R 1999 J. Appl. Ecol. 36 1
[7]	Kieffel Y et al 2016 IEEE Power Energy Mag. 14 32
[8]	Mantilla J D et al 2014 Investigation of the insulation performance of a new gas mixture with extremely low GWP Proc. 2014 IEEE Electrical Insulation Conf. (Philadelphia,PA) (Piscataway, NJ: IEEE)
[9]	Word Meteorological Organization 2014 World Meteorological Organization Global Ozone Research and Monitoring Project Report No. 56 United Nations Environment Programme
[10]	Yang L and Da Rocha S R 2014 J. Phys. Chem. B 118 10675
[11]	Clayton J W 1967 Fluorine Chem. Rev. 2 197
[12]	Rabie M and Franck C M 2015 IEEE Trans. Dielectr. Electr.Insul. 22 196
[13]	Elsheikh M Y and Fellenger P D 1999 Preparation of 1,1,1,3-tetrafluoropropene (1234ze) EP 0974571 Atofina Chem Inc.
[14]	Cottrell S A et al 2016 Manufacturing process for HFO-1234ze US 9255046 Honeywell International Inc.
[15]	Yamamoto A et al 2002 Process for producing 1,1,1,3,3-pentafluoropropane US 6472573 JP Daikin Industries, Ltd
[16]	Lesaint O et al 2018 A study of breakdown properties of HFO gas under DC and impulse voltage Proc. 2018 IEEE Conf.on Electrical Insulation and Dielectric Phenomena (Cancun, Mexico, 2018) (Piscataway, NJ: IEEE) (https://doi.org/10.1109/CEIDP.2018.8544877)
[17]	Koch M and Franck C M 2015 IEEE Trans. Dielect. Electr.Insul. 22 3260
[18]	Chachereau A and Franck C 2017 Characterization of HFO1234ze mixtures with N2 and CO2 for use as gaseous electrical insulation media 20th International Symposium on High Voltage Engineering (Buenos Aires, Argentina, 2017)(ISH) (https://doi.org/10.3929/ethz-b-000184288)
[19]	Chachereau A, Rabie M and Franck C M 2016 Plasma Sources Sci. Technol. 25 045005
[20]	Preve C, Piccoz D and Maladen R 2017 CIRED-Open Access Proc. J. 1 42
[21]	Tang J et al 2012 IEEE Trans. Dielectr. Electr. Insul. 19 29
[22]	Tang J et al 2012 IEEE Trans. Dielectr. Electr. Insul. 19 37
[23]	Higashi Y et al 2010 J. Chem. Eng. Data 55 1594
[24]	Nicola G D et al 2011 Fluid Phase Equilib. 8 351

[1]	S PUROHIT, Y SUZUKI, S OHDACHI, S YAMAMOTO. Soft x-ray tomographic reconstruction of Heliotron J plasma for the study of magnetohydrodynamic equilibrium and stability[J]. Plasma Science and Technology, 2019, 21(6): 65102-065102. DOI: 10.1088/2058-6272/ab0846
[2]	Luying NIU(牛璐莹), Hongrui CAO (曹宏睿), Kun XU(徐坤), Liqun HU(胡立群). Neutronic analysis of ITER radial x-ray camera[J]. Plasma Science and Technology, 2019, 21(2): 25601-025601. DOI: 10.1088/2058-6272/aaeba5
[3]	Xinshuai YANG (杨新帅), Ruiji HU (胡睿佶), Jun CHEN (陈俊), Fudi WANG (王福地), Jia FU (符佳), Yingying LI (李颖颖), Hongming ZHANG (张洪明), Yongcai SHEN (沈永才), Xianghui YIN (尹相辉), Bo LYU (吕波), EAST team. Measurement of impurity lines with two- crystal x-ray spectrometers on EAST[J]. Plasma Science and Technology, 2018, 20(12): 124001. DOI: 10.1088/2058-6272/aad177
[4]	Yue HUA (滑跃), Jian SONG (宋健), Zeyu HAO (郝泽宇), Gailing ZHANG (张改玲), Chunsheng REN (任春生). Effects of direct current discharge on the spatial distribution of cylindrical inductivelycoupled plasma at different gas pressures[J]. Plasma Science and Technology, 2018, 20(1): 14005-014005. DOI: 10.1088/2058-6272/aa8ea8
[5]	CHEN Zhaoxi (陈肇玺), HU Liqun (胡立群), CHENG Yong (程勇), LEI Mingzhun (雷明准), et al.. The Design and Test of a Be Window for the ITER Radial X-Ray Camera[J]. Plasma Science and Technology, 2013, 15(11): 1160-1164. DOI: 10.1088/1009-0630/15/11/15
[6]	SONG Tianming (宋天明), YANG Jiamin (杨家敏), YANG Dong (杨冬), et al.. Experimental Study of the X-Ray Radiation Source at Approximately Constant Radiation Temperature[J]. Plasma Science and Technology, 2013, 15(11): 1108-1111. DOI: 10.1088/1009-0630/15/11/06
[7]	ZHANG Xiaoding (张小丁), ZHANG Jiyan (张继彦), YANG Guohong (杨国洪), et al.. A High-Efficiency X-Ray Crystal Spectrometer for X-Ray Thomson Scattering[J]. Plasma Science and Technology, 2013, 15(8): 755-759. DOI: 10.1088/1009-0630/15/8/07
[8]	T. Abdul KAREEM, A. Anu KALIANI. X-Ray Diffraction Study of Plasma Exposed and Annealed AlSb Bilayer Thin Film[J]. Plasma Science and Technology, 2013, 15(4): 382-385. DOI: 10.1088/1009-0630/15/4/13
[9]	HU Guangyue (胡广月), ZHANG Xiaoding (张小丁), ZHENG Jian (郑坚), LEI An-le (雷安乐), SHEN Baifei (沈百飞), XU Zhizhan, et al. Demonstration of X-ray Thomson Scattering on Shenguang-Ⅱ Laser Facility[J]. Plasma Science and Technology, 2012, 14(10): 864-870. DOI: 10.1088/1009-0630/14/10/02
[10]	LIN Caishou (林才寿), MAO Li (毛莉), HUANG Ning (黄宁), AN Zhu (安竹). Simulation Study of Quantitative X-Ray Fluorescence Analysis of Ore Slurry Using Partial Least-Squares Regression[J]. Plasma Science and Technology, 2012, 14(5): 427-430. DOI: 10.1088/1009-0630/14/5/22

Cited By

Get Citation

PDF

XML

Article views (160) PDF downloads (256)

Turn off MathJax

Article Contents

Abstract

References

Study of partial discharge characteristics in HFO-1234ze(E)/N₂ mixtures

Abstract

References

Related Articles

Catalog

Study of partial discharge characteristics in HFO-1234ze(E)/N2 mixtures

Abstract

References

Related Articles

Catalog

Export File

Citation

Format

Content

Study of partial discharge characteristics in HFO-1234ze(E)/N₂ mixtures